CHAPTER 1. INTRODUCTION
GENERAL INFORMATION
SPECIAL INSTRUCTIONS. - TM-1-1510-225-MTF_13
SPECIAL INSTRUCTIONS. - TM-1-1510-225-MTF_13_copy1
Free Air Temperature (FAT) and Outside Air Temperature
CHAPTER 2. MAINTENANCE TEST FLIGHT CHECKLIST
PRIOR TO MAINTENANCE TEST FLIGHT (CONT) - TM-1-1510-225-MTF_16
PRIOR TO MAINTENANCE TEST FLIGHT (CONT) - TM-1-1510-225-MTF_17
PRIOR TO MAINTENANCE TEST FLIGHT (CONT) - TM-1-1510-225-MTF_18
PRIOR TO MAINTENANCE TEST FLIGHT (CONT) - TM-1-1510-225-MTF_19
PRIOR TO MAINTENANCE TEST FLIGHT (CONT) - TM-1-1510-225-MTF_20
ENG FIRE SYS TEST SWITCH
INTERIOR CHECK - TM-1-1510-225-MTF_22
Cargo door
BEFORE STARTING ENGINES
Pilots clock
Pedestal
Copilots clock
External power advisory light
FIRST ENGINE START (BATTERY START)
CONDITION lever
SECOND ENGINE START (BATTERY START)
IGNITION AND ENGINE START - TM-1-1510-225-MTF_32
ABORT START - TM-1-1510-225-MTF_33
FIRST ENGINE START (CPU START)
IGNITION AND ENGINE START - TM-1-1510-225-MTF_35
SECOND ENGINE START (CPU START)
IGNITION AND ENGINE START - TM-1-1510-225-MTF_37
AVIONICS MASTER PWR
BEFORE TAXIING
Brake deice
Brakes-Check
ENGINE RUNUP
HIGH IDLE
BLEED AIR VALVES switches
Rudder boost
AUTOFEATHER - TM-1-1510-225-MTF_46
Primary governors - TM-1-1510-225-MTF_47
Engine anti-ice - TM-1-1510-225-MTF_48
Weather radar .
Flight control/autopilot system
Press right rudder
Autopilot - TM-1-1510-225-MTF_52
Ground proximity altitude advisory system
Pressurization - TM-1-1510-225-MTF_54
BEFORE TAKEOFF - TM-1-1510-225-MTF_55
LINEUP
AFTER TAKEOFF - TM-1-1510-225-MTF_57
CLIMB
Propeller deice system
PILOT WSHLD ANTI-ICE
CRUISE
Pilots alternate static air source
Engine ice vanes - TM-1-1510-225-MTF_63
Trim and rigging
Airspeed - TM-1-1510-225-MTF_65
Airspeed - TM-1-1510-225-MTF_66
Stall speed
Propeller feathering
Engine cleanup
VENT BLOWER
IGNITION and ENGINE START switch - ON
AUTOFEATHER switch
Engine restart
IGNITION AND ENGINE START
Electrical equipment
Landing gear normal operation
DESCENT AND LOW LEVEL CRUISE - TM-1-1510-225-MTF_77
Elevator trim
Cabin controller
BEFORE LANDING
GO-AROUND - TM-1-1510-225-MTF_81
ENGINE SHUTDOWN - TM-1-1510-225-MTF_82
POWER levers
STANDBY PUMP switches
CHAPTER 3. TROUBLESHOOTING
Engine fails to light up
TROUBLESHOOTING GUIDE B - INSTRUMENTS CONDITIO
Fuel quantity indicator fluctuates or reads low
Zero or low voltage indicated
Low generator output.
Complete failure of battery to operate
Landing gear fails to retract
Landing gear fails to extend
Landing gear circuit breaker trips
Landing gear handle light inoperative
Stall warning system inoperative
Standby fuel pump inoperative. - TM-1-1510-225-MTF_97
Ventilation blower will not run. - TM-1-1510-225-MTF_98
Propeller deice inoperative.
TROUBLESHOOTING GUIDE E - POWERPLANT CONDITION
TROUBLESHOOTING GUIDE E - POWERPLANT CONDITION (cont)
Excessive engine oil consumption
Flame out.
Fluctuating torque indication.
Fluctuating gas generator speed.
Propeller governor test system inoperative on one engine.
Propeller slow to feather
TROUBLESHOOTING GUIDE G - HYDRAULIC CONDITIO
TROUBLESHOOTING GUIDE H - FLIGHT CON- TROLS
Cannot establish VHF two-way communications
HF transmitted or received signal or sidetone not clear
Radar inoperative
CHAPTER 4. SPECIAL PROCEDURES
GENERAL - TM-1-1510-225-MTF_114
TRIM AND RIGGING
SPEED PERFORMANCE AT MAXIMUM CRUISE POWER
ENGINE PERFORMANCE AT MAXIMUM CON- TINUOUS POWER
ENGINE PERFORMANCE AT MAXIMUM CRUISE POWER
AVIONICS FLIGHT CHECKS
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_120
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_121
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_122
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_123
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_124
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_125
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_126
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_127
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_128
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_129
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_130
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_131
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_132
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_133
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_134
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_135
CHAPTER 5. CHARTS AND FORMS
Figure 1. Propeller Low Pitch Stop
figure 2. stall speed
Figure 3. Airspeeds for Vmo Dive
Figure 4. Maximum Cruise Speed and Power {Sheet 1 of 2)
Figure 4. Maximum Cruise Speed and Power (Sheet 2 of 2)
Figure 5. Maximum Continuous Power
Figure 6. Maximum Cruise Power
fiure 7. maintenance test flight checksheet (sheet 1 of 3)
fiure 7. maintenance test flight checksheet (sheet 2 of 3)
fiure 7. maintenance test flight checksheet (sheet 3 of 3)
THE METRIC SYSTEM AND EQUIVALENTS Linear Measure 1 centimeter = 10 millimeters = .39 inch 1 decimeter = 10 centimeters = 3.94 inches 1 meter = 10 decimeters = 39.37 inches 1 dekameter = 10 meters = 32.8 feet 1 hectometer = 10 dekameters = 328.08 feet 1 kilometer = 10 hectometers = 3280.8 feet Weights 1 centigram = 10 milligrams = .15 grain 1 decigram = 10 centigrams = 1.54 grains 1 gram = 10 decigrams = .035 ounce 1 dekagram = 10 grams = .35 ounce 1 hectogram = 10 dekagrams = 3.52 ounces 1 kilogram = 10 hectograms=2.2 pounds 1 quintal = 100 kilograms = 220.46 pounds 1 metric ton = 10 quintals: 1.1 short tons Liquid Measure 1 centiliter = 10 milliliters = .34 fl. ounces 1 deciliter = 10 centiliters = 3.38 fl. ounces 1 liter = 10 deciliters = 33.81 fl. ounces 1 dekalfter = 10 liters = 2.64 gallons 1 hectoliter = 10 dekaltters = 28.42 gallons 1 kiloliter = 10 hectoliters = 264.18 gallons
GENERAL INFORMATION
SPECIAL INSTRUCTIONS. - TM-1-1510-225-MTF_13
SPECIAL INSTRUCTIONS. - TM-1-1510-225-MTF_13_copy1
Free Air Temperature (FAT) and Outside Air Temperature
CHAPTER 2. MAINTENANCE TEST FLIGHT CHECKLIST
PRIOR TO MAINTENANCE TEST FLIGHT (CONT) - TM-1-1510-225-MTF_16
PRIOR TO MAINTENANCE TEST FLIGHT (CONT) - TM-1-1510-225-MTF_17
PRIOR TO MAINTENANCE TEST FLIGHT (CONT) - TM-1-1510-225-MTF_18
PRIOR TO MAINTENANCE TEST FLIGHT (CONT) - TM-1-1510-225-MTF_19
PRIOR TO MAINTENANCE TEST FLIGHT (CONT) - TM-1-1510-225-MTF_20
ENG FIRE SYS TEST SWITCH
INTERIOR CHECK - TM-1-1510-225-MTF_22
Cargo door
BEFORE STARTING ENGINES
Pilots clock
Pedestal
Copilots clock
External power advisory light
FIRST ENGINE START (BATTERY START)
CONDITION lever
SECOND ENGINE START (BATTERY START)
IGNITION AND ENGINE START - TM-1-1510-225-MTF_32
ABORT START - TM-1-1510-225-MTF_33
FIRST ENGINE START (CPU START)
IGNITION AND ENGINE START - TM-1-1510-225-MTF_35
SECOND ENGINE START (CPU START)
IGNITION AND ENGINE START - TM-1-1510-225-MTF_37
AVIONICS MASTER PWR
BEFORE TAXIING
Brake deice
Brakes-Check
ENGINE RUNUP
HIGH IDLE
BLEED AIR VALVES switches
Rudder boost
AUTOFEATHER - TM-1-1510-225-MTF_46
Primary governors - TM-1-1510-225-MTF_47
Engine anti-ice - TM-1-1510-225-MTF_48
Weather radar .
Flight control/autopilot system
Press right rudder
Autopilot - TM-1-1510-225-MTF_52
Ground proximity altitude advisory system
Pressurization - TM-1-1510-225-MTF_54
BEFORE TAKEOFF - TM-1-1510-225-MTF_55
LINEUP
AFTER TAKEOFF - TM-1-1510-225-MTF_57
CLIMB
Propeller deice system
PILOT WSHLD ANTI-ICE
CRUISE
Pilots alternate static air source
Engine ice vanes - TM-1-1510-225-MTF_63
Trim and rigging
Airspeed - TM-1-1510-225-MTF_65
Airspeed - TM-1-1510-225-MTF_66
Stall speed
Propeller feathering
Engine cleanup
VENT BLOWER
IGNITION and ENGINE START switch - ON
AUTOFEATHER switch
Engine restart
IGNITION AND ENGINE START
Electrical equipment
Landing gear normal operation
DESCENT AND LOW LEVEL CRUISE - TM-1-1510-225-MTF_77
Elevator trim
Cabin controller
BEFORE LANDING
GO-AROUND - TM-1-1510-225-MTF_81
ENGINE SHUTDOWN - TM-1-1510-225-MTF_82
POWER levers
STANDBY PUMP switches
CHAPTER 3. TROUBLESHOOTING
Engine fails to light up
TROUBLESHOOTING GUIDE B - INSTRUMENTS CONDITIO
Fuel quantity indicator fluctuates or reads low
Zero or low voltage indicated
Low generator output.
Complete failure of battery to operate
Landing gear fails to retract
Landing gear fails to extend
Landing gear circuit breaker trips
Landing gear handle light inoperative
Stall warning system inoperative
Standby fuel pump inoperative. - TM-1-1510-225-MTF_97
Ventilation blower will not run. - TM-1-1510-225-MTF_98
Propeller deice inoperative.
TROUBLESHOOTING GUIDE E - POWERPLANT CONDITION
TROUBLESHOOTING GUIDE E - POWERPLANT CONDITION (cont)
Excessive engine oil consumption
Flame out.
Fluctuating torque indication.
Fluctuating gas generator speed.
Propeller governor test system inoperative on one engine.
Propeller slow to feather
TROUBLESHOOTING GUIDE G - HYDRAULIC CONDITIO
TROUBLESHOOTING GUIDE H - FLIGHT CON- TROLS
Cannot establish VHF two-way communications
HF transmitted or received signal or sidetone not clear
Radar inoperative
CHAPTER 4. SPECIAL PROCEDURES
GENERAL - TM-1-1510-225-MTF_114
TRIM AND RIGGING
SPEED PERFORMANCE AT MAXIMUM CRUISE POWER
ENGINE PERFORMANCE AT MAXIMUM CON- TINUOUS POWER
ENGINE PERFORMANCE AT MAXIMUM CRUISE POWER
AVIONICS FLIGHT CHECKS
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_120
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_121
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_122
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_123
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_124
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_125
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_126
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_127
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_128
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_129
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_130
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_131
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_132
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_133
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_134
AVIONICS FLIGHT CHECKS (CONT) - TM-1-1510-225-MTF_135
CHAPTER 5. CHARTS AND FORMS
Figure 1. Propeller Low Pitch Stop
figure 2. stall speed
Figure 3. Airspeeds for Vmo Dive
Figure 4. Maximum Cruise Speed and Power {Sheet 1 of 2)
Figure 4. Maximum Cruise Speed and Power (Sheet 2 of 2)
Figure 5. Maximum Continuous Power
Figure 6. Maximum Cruise Power
fiure 7. maintenance test flight checksheet (sheet 1 of 3)
fiure 7. maintenance test flight checksheet (sheet 2 of 3)
fiure 7. maintenance test flight checksheet (sheet 3 of 3)
THE METRIC SYSTEM AND EQUIVALENTS Linear Measure 1 centimeter = 10 millimeters = .39 inch 1 decimeter = 10 centimeters = 3.94 inches 1 meter = 10 decimeters = 39.37 inches 1 dekameter = 10 meters = 32.8 feet 1 hectometer = 10 dekameters = 328.08 feet 1 kilometer = 10 hectometers = 3280.8 feet Weights 1 centigram = 10 milligrams = .15 grain 1 decigram = 10 centigrams = 1.54 grains 1 gram = 10 decigrams = .035 ounce 1 dekagram = 10 grams = .35 ounce 1 hectogram = 10 dekagrams = 3.52 ounces 1 kilogram = 10 hectograms=2.2 pounds 1 quintal = 100 kilograms = 220.46 pounds 1 metric ton = 10 quintals: 1.1 short tons Liquid Measure 1 centiliter = 10 milliliters = .34 fl. ounces 1 deciliter = 10 centiliters = 3.38 fl. ounces 1 liter = 10 deciliters = 33.81 fl. ounces 1 dekalfter = 10 liters = 2.64 gallons 1 hectoliter = 10 dekaltters = 28.42 gallons 1 kiloliter = 10 hectoliters = 264.18 gallons
